BASE F (WITEPSOL) 1KG by Letco Medical Safety Data Sheet Section 1: Identification Common Name/Trade Name BASE F (WITEPSOL H 15) Supplier Information Letco Medical, LLC 1316 Commerce Drive NW Decatur, AL 35601 1 (800) 239-5288 +1 (734) 843-4693 IN CASE OF EMERGENCY: Chemtrec 1 (800) 424-9300 (24 hours) Product Synonym(s) Glycerides, C12-18- Relevant Use(s) of Product Manuf acture or Compounding of Substances Section 2: Hazards Identification Classification of Substance or Mixture Not a hazardous substance or mixture. Signal Word None Hazard Statement(s) N/A Pictogram(s) N/A Precautionary Statement(s) N/A Hazards Not Otherwise Classified No data available Ingredient(s) with Unknown Toxicity No data Available Section 3: Composition/Information on Ingredients Chemical Name Mixture based on: Glycerides, C12-18- Common Name WITEPSOL H 15 CAS Number 67701-26-2 Additional Ingredient Information Dangerous components: Void Impurities and/or Stabilizing Additives No data available Section 4: First Aid Measures General Advice If symptoms persist or in case of doubt, seek medical advice. If Inhaled Supply fresh air; consult a doctor in case of pain. In Case of Skin Contact Wash with water and soap. If symptoms persist, consult a doctor. In Case of Eye Contact Rinse opened eye f or several minutes under running water. If symptoms persist, consult doctor. If Swallowed Rinse mouth with water. Seek medical treatment. Do not induce vomiting. Unless instructed explicitly by medical staf f . Never give anything by mouth to an unconscious person. In case of unintentional swallowing of larger quantities or if any symptoms occur seek medical treatment. Most Important Symptoms and Effects Most important symptoms and ef f ect, both acute and delayed. No f urther relevant inf ormation available. Symptomatic treatment. Section 5: Fire Fighting Measures Suitable Extinguishing Media Fire-extinguishing powder, Carbon dioxide (CO2) Foam. Use f ire f ighting measures that suit the environment. Unsuitable extinguishing agent: High volume water jet. Special Hazards Arising From the Substance/Mixture In case of f ire, the f ollowing can be released. Carbon monoxide, (CO) Carbon dioxide (CO2). Special PPE and/or Precautions for Firefighters Wear self contained respiratory protective device. Additional inf ormation: Cool endangered receptacles with water spray. Section 6: Accidental Release Measures Personal Precautions, Protective Equipment and Emergency Procedures Wear protective clothing. Product f orms slippery surf ace when combined with water. Particular danger slipping on leaked/spilled product. Methods and Materials Used for Containment No special measures required. Cleanup Procedures Pick up mechanically. Make sure to recycle or dispose of in suitable receptacles. Page 1 of 4 Section 7: Handling and Storage Precautions for Safe Handling No special precautions are necessary if used properly. Keep ignition sources away- Do not smoke. Observe general rules of industrial f ire protection. Conditions for Safe Storage Store container tightly sealed at a cool and dry place with suf f icient ventilation. Store away from f oodstuf f s. Store away from f eed. Ref er to national regulations f or storing hazardous chemicals. Storage class: 11 Combustible solids. Section 8: Exposure Controls/Personal Protection Components with Workplace Control Parameters The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace. 67701-26-2 Glycerides, C12-18: Oral DNEL/Cons/LSE 17.115 mg/kg bw/day (human), Dermal DNEL/Cons/LSE 17.115 mgl/kg bw/day (human), DNEL/In/LSE 34.23 mg/kg bw/day (human). Inhalative DNLE/Cons/LSE 59.53 mg/m3 (human), DNEL/In/LSE 241.41 mg/m3 (human). Appropriate Engineering Controls The usual precautionary measures should be adhered to when handling chemicals. Wash hands bef ore breaks and at the end of work. Use skin protection cream f or skin protection. PPE - Eye/Face Protection Saf ety glasses. PPE - Skin Protection Protective gloves. Af ter use of gloves, apply skin-cleaning agents and skin cosmetics. The glove material has to be impermeable and resistant to the product/substance/preparation. Selection of the glove material in consideration of the penetration times, rates of dif f usion and the degradation. Material of gloves: Nitrile rubber, NBR, Butyl rubber, BR. The selection of suitable gloves depends upon the material, and also upon the quality of the gloves. The degree of protection will vary from manuf acturer to manuf acturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has theref ore to be checked prior to the application. For the permanent contact gloves made of the f ollowing materials are suitable: Nitril rubber, NBR (Thickness: 0.35 mm; Permeation time: >/= 480 minutes) butyl rubber, BR. (Thickness: 0.5 mm; Permeation time: >/= 480 Minutes) PPE - Body Protection Protective work clothing. PPE - Respiratory Protection Not necessary if room is well-ventilated. At f ormation of dust: Short term f ilter device: Filter P1, Filter P2. Section 9: Physical and Chemical Properties Appearance Solid material. Pellets. White. Upper/Lower Flammability or Explosive Limits No data available Odor Odorless Vapor Pressure No data available Odor Threshold No data available Vapor Density No data available pH No data available Relative Density ~0.95 g/cm3 Melting Point/Freezing Point ~31-38C Solubility Practically insoluble in water. Initial Boiling Point and Boiling Range No data available Flash Point >200C (DIN ISO 2592) Evaporation Rate Not applicable Flammability (Solid, Gas) Not determined Partition Coefficient Not determined Auto-Ignition Temperature Product is not self-igniting. Decomposition Temperature No data available Viscosity Not applicable Section 10: Stability and Reactivity Reactivity No f urther relevant inf ormation available Chemical Stability To avoid thermal decomposition do not overheat. No decomposition if used and stored according to specif ications. Possibility of Hazardous Reactions No dangerous reactions known. Conditions to Avoid Strong heating, dirt, chemical contamination, Sunlight, UV or ionizing radiation. Incompatible Materials No f urther relevant inf ormation available. Hazardous Decomposition Products No hazardous decomposition products if instructions f or storage and handling are f ollowed. Page 2 of 4 Section 11: Toxicological Information Acute Toxicity - LD50 Oral Based on available data, the classif ication criteria are not met. Acute Toxicity - Inhalation No toxicity data are available f or the product itself . 67701-26-2 Glycerides, C12-18: Oral LD50 >2000 mg/kg (rat) (OECD 401), Dermal LD50 >2000 mg/kg (rat) Literature. Inhalative LC50/6h > 1.86 mg/l (rat) (OECD 403) Literature. Acute Toxicity - Dermal No toxicity data are available f or the product itself . Acute Toxicity - Eye No irritating ef f ect. Skin Corrosion/Irritation Skin irritation test (rabbit): no irritation. Serious Eye Damage/Irritation Skin irritation test (rabbit) no irritation. Respiratory or Skin Sensitazation No sensitization species: guinea pig OECD 406 (Buehler Test) Germ Cell Mutagenicity Based on available data, the classif ication criteria are not met. Carcinogenicity IARC Based on available data, the classif ication criteria are not met. Carcinogenicity ACGIH Based on available data, the classif ication criteria are not met. Carcinogenicity NTP Based on available data, the classif ication criteria are not met. Carcinogenicity OSHA Based on available data, the classif ication criteria are not met. Reproductive Toxicity 67701-26-2 Glycerides, C12-18: Oral NOAEL 1000 mg/kg bw/day (rat) (OECD 422), NOAEL (F1) 1000 mg/kg bw/day (rat) (OECD 422) 49 d Literature, substance: glycerides, C8-18 and C18 unsaturated mono- and di-, acetate. NOAEL (P) 1000 mg/kg bw/day (rat) (OECD 422) 49 d Literature, substance: glycerides, C8-C18 and C18 unsaturated mono- and di-, acetate. Based on available data, the classif ication are not met. Specific Target Organ Toxicity - Single Exposure Based on the available data, the classif ication criteria are not met. Specific Target Organ Toxicity - Repeated Exposure Based on the available data, the classif ication criteria are not met. Aspiration Hazard Not relevant Section 12: Ecological Information Toxicity No harmf ul ef f ect on f ish, daphnia and algae up to its limit of solubility. Persistence and Degradability Readily biodegradable. Biological degradation: >60% af ter 28 days. OECD 301 F. Bio-accumulative Potential No bioaccumulation to be expected. Conclusion by analogy. Mobility in Soil Strong absorption to soil Other Adverse Effects No f urther relevant inf ormation available. Section 13: Disposal Considerations Waste Treatment Methods Product Must be recycled or disposed of according to the regulations. Waste has to be classif ied according to the European Waste Catalogue based on the identif ication of the waste generating source. Disposal according to instructions of local authorities. Waste Treatment Methods Packaging Disposal must be made according to of f icial regulations. Packagings that cannot be cleaned are to be disposed of in the same manner as the product. If not of f icially regulated, non contaminated packagings can be used f or recycling or treated like household garbage. Special Precautions Landfill or Incinerations No data available Other Information No data available Section 14: Transport Information UN Number Not dangerous goods UN Proper Shipping Name N/A Transport Hazard Class(es) N/A Packaging Group N/A Environmental Hazards N/A Section 15: Regulatory Information Named dangerous substances - ANNEX I None of the ingredients is listed. Water hazard class: Generally not hazardous f or water. Further inf ormation: For this substance/mixture no saf ety data sheet needs to be generated according to Article 31 (1) of Regulation (EC) No 1907/2006. The here presented saf ety data sheet may theref ore not f ulf ill all requirements of Annex II of this regulation. A Chemical Saf ety Assessment has not been carried out. Page 3 of 4 Section 16: Other Information Additional Information N/A Prepared By Scarlotte Smith Revision Date 01/29/2019 17:17 Disclaimer Letco Medical, LLC believes that the above information is correct but does not purport to be all inclusive and shall be used only as a guide. The information in this document is based on the present state of our knowledge and is applicable to the product with regard to appropriate safety precautions. If the product is used as a component in another product, this information may not be applicable. NO WARRANTY OF FITNESS FOR ANY PARTICULAR PURPOSE, WARRANTY OF MERCHANTABILITY OR ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, IS MADE CONCERNING THE INFORMATION PROVIDED ABOVE. Letco Medical shall not be held liable for any loss or damage resulting from handling, storage, use or from contact with the above product. Page 4 of 4
